Millard Refrigerated Services was fined $3 million for alleged violations of the Clean Air Act, Emergency Planning and Community Right-to-Know Act and Comprehensive Environmental Response, Compensation, and Liability Act violations for an airborne release of ammonia from Millard’s Theodore, Alabama, facility in 2010.

Millard will pay a $3 million penalty for the violations that sickened 152 people responding to the BP oil spill.

Millard entered into a settlement agreement.

The company was represented by Adam G. Sowatzka of King & Spalding in Atlanta.

On August 23, 2010, the Millard Refrigerated Service warehouse in Theodore, Alabama, released approximately 32,000 pounds of anhydrous ammonia, to which exposure can be lethal, into the air after refrigeration equipment malfunctioned.

The ammonia traveled directly over a site where more than 800 people were working on decontaminating ships responding to the Deepwater Horizon oil spill in the Gulf of Mexico.

The Mobile, Alabama, Emergency Management Agency ordered an evacuation of the surrounding area and a one mile shelter in place situation following the ammonia release.

One hundred fifty-two people working at the site and on ships were treated for symptoms of ammonia exposure at hospitals in the Mobile area, four of whom were admitted into intensive care units.

One Millard employee sustained injuries after briefly losing consciousness from ammonia inhalation.

During its investigation of the warehouse after the ammonia release, EPA discovered that Millard failed to adequately address a well-known risk for ammonia production systems called hydraulic shock, which can cause catastrophic equipment failures.

These failures can lead to hazardous releases of anhydrous ammonia.

The company’s failure to address this risk, in addition to other deficiencies in its production and safety systems, amounted to 37 distinct violations of the Clean Air Act’s Risk Management Program and General Duty Clause.

These requirements compel companies that store or use potentially-hazardous substances like ammonia to identify the hazards posed by their operation, design and maintain a safe facility and minimize the consequences of any releases that might occur.

The company’s failure to immediately report a release of anhydrous ammonia above the reportable quantity to the National Response Center amounted to one CERCLA violation.

The company’s failure to immediately report a release of anhydrous ammonia to the local and state emergency planning commissions and to file a follow-up reports for two releases amounted to three EPCRA violations.

EPA also discovered that Millard had two prior smaller ammonia releases caused by hydraulic shock, which should have signaled a need to take steps to prevent a catastrophic release like the one that occurred at the Theodore warehouse.

Millard sold the Theodore warehouse facility, which is no longer in operation.